NGB courses

/NGB courses

Gas canister explosion ML Course

ML courses

Gas canister explosion

Gas canister explosion on a recent ML Assessment course.

This happened on a very still day.  The stove had been used about 10 mins before the explosion, was turned off and still had the stove screwed into the canister.

We believe the stove was turned off properly but may have been not quite tight enough.

It seems that because it was a very still day and the lack of wind (which is not normally an issue  in the Lake District) the gas that was slightly leaking from the canister did not disperse.  Gas is heavy and sinks to the ground and runs down hill.

When Andy the assessor light up his stove outside his tent about 10 meters away from the other stove it almost instantly caused the other canister to ignite and explode about 10 meters into the air.

It caused a small shock wave and also sent the pan, stove and canister into the air.  The group collected all the bits and thankfully no one was hurt.

I have had a candidate on a previous training that had at an earlier time prior to the training course had a canister explode in his face which did cause him severe injuries.

He said that on that occasion it was again a very still day and he was also outside and a reasonable distance from another stove.  In this case as he was screwing the stove onto the canister it let out some gas,  he unscrewed it so see if there was any dirt or if he had cross threaded it but all looked OK, so he tried again screwing the stove and canister together, again some gas came out and at this point the canister ignited and blow up burning his face…

 

Some thoughts on lessons learned

I guess we must not assume that gas canisters are full proof and that on very still days a very small amount of gas can stay around the area.  Perhaps we should think about storing canisters detached from the stoves and if in any doubt move them away from camp for storage.  Please email if you have any further info on this or contact Mark walker at the MT office as they are very keen to share learning experiences.

Cheers Stuart

 

By |2014-08-29T15:38:29+01:00July 29th, 2014|NGB courses|0 Comments

SPA Assessment Blog

SPA Assessment course Lake District

If you want to book onto an SPA assessment course click here

SPA Assessment

Lower Scout Crag

OLYMPUS DIGITAL CAMERA

Adam at Hutton roof

SPA Assessment 13

Wild Thyme

SPA Assessment

Dan with the big hex

SPA Assessment

Hutton Roof SSSI

SPA Assessment

James enjoying the dry Limestone

SPA Assessment

Abseil rescue pick up

SPA Assessment

Dam & James at Stickle barn crag

SPA Assessment

Playing Hool a hoop

SPA Assessment

Putting on clothes game

SPA Assessment

Below Lower Scout crag

SPA Assessment

Equalising anchors using the rope with a big bight of over hand then clove hitch on either side.

By |2017-01-31T16:36:03+01:00June 28th, 2014|NGB courses|0 Comments